自動攪拌車因機動性強，占用場地少，操作簡便，運行可靠等特點，廣泛應用于混凝土小型構件、圍擋、涵洞等野外施工中。同時，由于其用電量不大、臨時性顯著，操作技能要求低等因素，而往往成為生產管理的薄弱點，電源接入、配電線路、配電箱、開關箱以及機械防護等常常存在諸多隱患。

The automatic mixer is widely used in the field construction of small concrete components, fences, culverts, etc. due to its strong mobility, less occupation of site, simple operation and reliable operation. At the same time, because of its small power consumption, significant temporary, low operating skill requirements and other factors, it often becomes the weak point of safety production management. There are many potential safety hazards in power supply access, distribution lines, distribution boxes, switch boxes and mechanical protection.

1、接入電源未按規定設置配電箱，無配電箱，或配電箱無門、無鎖、無防雨措施，接線不規范。

1. The power supply is connected without distribution box as required, or the distribution box has no door, lock, rainproof measures, and the wiring is not standardized.

2、電源接線未按規定架空或填埋（違規直接沿地面敷設）。

2. The power wiring is not overhead or buried as required (it is directly laid along the ground in violation of regulations).

3、違規使用護套線或代替橡膠電纜（尤其是動力纜線）。

3. Use sheathed cable or replace rubber cable (especially power cable) in violation of regulations.

4、纜線護套嚴重破損。

4. The cable sheath is seriously damaged.

5、無開關箱、無漏電保護器或開關箱無漏電保護器。

5. There is no switch box, leakage protector or leakage protector in the switch box.

此外這些事項也要做好，如：

In addition, these matters should also be done well, such as:

攪拌車在空載運行過程中，攪伴筒不得停轉以免顛簸時造成滾道和托輪局部磕碰，導致托輪和滾道的異常損壞。

In the process of no-load operation of the mixer, the mixing and tracing cylinder shall not stop to avoid local collision between the roller and the supporting wheel caused by turbulence, resulting in abnormal damage to the supporting wheel and the roller.

水箱的水量要經常加滿，以備急用。水箱加水前，打開放氣閥把箱內空氣放掉；沖洗時打開氣閥，沖洗完畢或者停用時應將水罐內氣體放掉。冬季停放時，水箱和供水系統里不得有剩余水，防止凍裂。

The water tank shall be filled frequently for emergency use. Before adding water to the water tank, open the vent valve to drain the air in the tank; Open the gas valve when flushing, and drain the gas in the water tank after flushing or when it is stopped. When parking in winter, there shall be no residual water in the water tank and water supply system to prevent frost cracking.

滿載混凝土正轉，如要反轉，須操縱手柄使正轉停穩后，再操縱手柄反轉。嚴禁正轉過程中操縱手柄使其反轉。

The full load concrete rotates forward. If it needs to reverse, the handle must be operated to make the forward rotation stop stably, and then the handle can reverse. It is forbidden to reverse the joystick during forward rotation.

以上就是有關自動攪拌車這些隱患一定要注意的問題的解答內容了，您對此有什么想咨詢的問題或者有什么需求，歡迎來我們網站http://kitchinit.com進行咨詢了解！

The above is the answer to the questions that must be paid attention to about the potential safety hazards of the automatic mixer. If you have any questions or needs, please come to our website http://kitchinit.com Ask about it!