蓄電池是自動上料攪拌車上一個關鍵的設備，可以供應汽車打火、供電系統的要求，一般的蓄電池是可以應用很長期的，但假如長期忘掉拆換或是是維護保養不足好的話，就很有可能會碰到忽然無電的狀況，這個時候攪拌車很有可能連起動都變成難題，就對于這一難題廠家為大伙兒出示二點方式:

The storage battery is a key equipment on the automatic feeding mixer, which can meet the requirements of the ignition and power supply system of the vehicle. Generally, the storage battery can be used for a long time. However, if the replacement is forgotten for a long time or the maintenance is not good enough, it is very likely to encounter a sudden lack of power. At this time, the mixer is likely to become a problem even for starting. The manufacturer presents two solutions to this problem:

一、鋼筋搭接起動。假如碰到狀況時也有同行業的車，車?yán)镆灿薪拥仉娎|時，還能夠選用蓄電池鋼筋搭接的方式起動車子。具體步驟時先將兩輛車挨近，直接地電纜充足聯接二塊蓄電池的正負。要留意保證兩輛車沒有觸碰，只容許應用具備充足的承載力且?guī)Ы^緣層表皮的電纜。假如出示開關電源的蓄電池在車子上的安裝部位不方便立即開展接地，則務必應用專用工具將蓄電池拆下來。

1、 Rebar lapping start. If there is a car in the same industry in case of a situation, and there is a grounding cable in the car, you can also start the car in the way of overlapping the battery reinforcement. In the specific steps, first approach the two vehicles until the grounding cable is sufficiently connected to the positive and negative of the two batteries. Pay attention to ensure that the two vehicles do not touch. Only cables with sufficient bearing capacity and insulation skin are allowed to be used. If the installation position of the battery with switching power supply on the vehicle is not convenient for immediate grounding, it is necessary to remove the battery with special tools.

明確二塊蓄電池的正級和負級，應用電纜將正級與正級、負級與負級各自連起來。要留意蓄電池的正負一定不要弄錯，并且要確保電纜的靠譜聯接。布局好電纜的走向，避免 起動時電纜與膠布或散熱風扇刮蹭。

Define the positive and negative stages of the two batteries, and connect the positive and negative stages and the negative and negative stages respectively with cables. Pay attention to the positive and negative of the battery, and make sure that the cable is connected reliably. Lay out the direction of the cable to avoid scratching the cable with the adhesive tape or the cooling fan when starting.

關掉車?yán)锶扛皆O(shè)用電量機器設備，起動出示開關電源的蓄電池所屬的車子，使其柴油發動機運行數分鐘以確保用電量充裕。隨后按一切正常方法起動沒電車子，起動后應輕踩加速踏板，使柴油發動機以2000r/min的轉速比運行數分鐘。隨后關掉兩輛車的啟動馬達，當心拆卸電纜，留意防止正負電纜連接頭碰撞。

Turn off all the auxiliary power consumption machines and equipment in the vehicle, start the vehicle with the battery showing the switching power supply, and run the diesel engine for several minutes to ensure sufficient power consumption. Then, start the car without electricity according to all normal methods. After starting, gently step on the accelerator pedal to make the diesel engine run at the speed ratio of 2000r / min for several minutes. Then, turn off the starting motors of the two vehicles, carefully remove the cables and prevent the positive and negative cable connectors from colliding.

二、牽引起動。牽引起動的方式與基本原理與手推車起動如出一轍，不一樣的是出行牽引通常省勁方便得多。落實措施時應用長短適度的牽引繩，并將兩邊綁扎牢固。

2、 Traction start. The mode and basic principle of traction starting are the same as that of trolley starting. The difference is that the traction is usually much more energy-saving and convenient. During the implementation of measures, the traction rope with appropriate length shall be used, and both sides shall be bound firmly.

在牽引前，前后左右車司機先要明確好聯系數據信號，比如發展和泊車是警笛提示還是做手勢提示，便于融洽相互配合。要慢速度發展，前車司機除應留意后車趨勢外，還應隨時隨地留意地面上的交通條件。后車司機在車子起動后應立即提示前車，兩輛車應遲緩挨近違章停車。

Before traction, drivers of front, rear, left and right vehicles should first make clear the contact data signals, such as whether the development and parking are siren prompts or gesture prompts, so as to facilitate harmonious cooperation. To develop at a slow speed, drivers in front should not only pay attention to the trend of vehicles behind, but also pay attention to the traffic conditions on the ground at any time. The driver of the rear vehicle shall prompt the front vehicle immediately after the vehicle starts, and the two vehicles shall slowly approach the illegal parking.

攪拌車蓄電池沒電了該怎么辦？以上兩點希望能夠給您帶來好的幫助，更多相關內容就來我們網站http://kitchinit.com咨詢吧。

What should I do if the battery of the mixer truck is dead? I hope the above two points can bring you good help. Come to our website for more relevant content http://kitchinit.com Consult.