The driver is used to drive the rotation of the concrete storage tank. It consists of power take-off, cardan shaft, hydraulic pump, hydraulic motor, control valve, hydraulic oil tank and cooling device. If a component fails due to a failure, the concrete tank will not rotate and the concrete in the vehicle will be discarded.

整個儲罐中的混凝土?xí)趦?chǔ)罐中凝結，從而形成全自動廢物攪拌機。因此，驅動器的可靠性在使用過程中非常重要。為確保驅動器處于良好狀態，您需要執行以下維護任務：

The concrete in the whole tank will set in the tank to form a fully automatic waste mixer. Therefore, the reliability of the drive is very important in the use process. To ensure that the drive is in good condition, you need to perform the following maintenance tasks:

通用旋轉零件是有缺陷的零件。必須及時補充潤滑脂，經常檢查是否磨損，并及時修理和更換。需要備用的萬向軸組件，因此如果在幾分鐘內發生故障，可以將其恢復。

Universal rotating parts are defective parts. It is necessary to replenish the grease in time, check whether it is worn frequently, and repair and replace it in time. A spare cardan shaft assembly is required, so if it fails within a few minutes, it can be restored.

檢查液壓油是否清潔。自上料攪拌車的工作環境差，必須將臟的水泥砂排除在液壓系統之外。必須根據手冊的要求定期更換流體。如果檢查表明液壓油中存在水或沙子，則必須立即關閉液壓系統，并更換液壓油。

Check whether the hydraulic oil is clean. Since the working environment of the self feeding mixer is poor, the dirty cement sand must be excluded from the hydraulic system. The fluid must be changed regularly according to the manual. If the inspection indicates the presence of water or sand in the hydraulic oil, the hydraulic system must be shut down immediately and the hydraulic oil must be replaced.

檢查液壓冷卻系統是否處于活動狀態。定期清潔液壓散熱器，以防止散熱器被水泥堵塞，檢查散熱器的電風扇是否正常工作，并保持液壓油溫度高于正常溫度。

Check that the hydraulic cooling system is active. Regularly clean the hydraulic radiator to prevent the radiator from being blocked by cement, check whether the electric fan of the radiator works normally, and keep the hydraulic oil temperature higher than the normal temperature.

只要液壓元件保證液壓油清潔，通常很少會發生故障，但是制造商的使用壽命會有所不同。

As long as the hydraulic components ensure that the hydraulic oil is clean, there are usually few failures, but the service life of the manufacturer will be different.

自上料混凝土攪拌車的驅動器維護了解就是這些，希望對你有幫助。

From the drive maintenance of the concrete mixer, I understand that. I hope it can help you.