The self loading mixing conveyor is a special heavy truck. When mixing fuel tanks, the load capacity is large and the road conditions become complex. Due to the increase of inertial centrifugal force, high requirements are put forward for the braking system of self feeding mixing conveyor system. The braking system is very important for the mixer system, but when determining the safety of the mixer, the first consideration is the braking distance of the lift car and the thermal degradation of the brake. If there is a problem with the truck's braking system, the driver and passengers are also at risk. Therefore, be careful when applying or applying the brake.

1.制動時發出異常聲音踩剎車時，剎車系統會引起強烈的金屬摩擦。原因可能是剎車片上的異物或剎車盤生銹。

1. Make abnormal sound when braking. When stepping on the brake, the brake system will cause strong metal friction. The reason may be foreign matters on the brake pad or rust on the brake disc.

2.制動踏板的行程變長剎車變軟時，您會看到筆直的白點。較長的制動沖程主要是由于空氣進入制動系統，缺少制動油，可能的泄漏和制動襯塊的嚴重磨損。

2. When the travel of the brake pedal becomes longer and the brake becomes soft, you will see straight white spots. The longer braking stroke is mainly due to air entering the braking system, lack of brake oil, possible leakage and serious wear of brake pads.

3.制動偏差制動器打滑不太常見，主要反映了在施加制動器時方向盤向一側彎曲的事實。造成這種現象的原因可能是制動襯塊偏心磨損和制動分泵出現問題。

3. Brake deviation brake slip is not common, which mainly reflects the fact that the steering wheel bends to one side when the brake is applied. This phenomenon may be caused by eccentric wear of brake pads and problems of brake wheel cylinder.

4.剎車越來越難許多卡都有增加制動的問題。加強制動器的主要原因是真空助力器故障。剎車不輔助，經常使用剎車。

4. Braking is becoming more and more difficult. Many cards have the problem of increasing braking. The main reason for strengthening the brake is the failure of the vacuum booster. The brake is not assisted, and the brake is often used.

5.剎車回彈許多卡伙伴都遇到過這種情況，但是在制動時，會出現一種現象，其中上肢從制動踏板上彈起，主要是由于制動盤表面不平整。墊片和鋼環變形。

5. Brake rebound many card partners have encountered this situation, but during braking, there will be a phenomenon, in which the upper limb bounces from the brake pedal, mainly due to the uneven surface of the brake disc. The gasket and steel ring are deformed.

以上就是自動上料攪拌車給大家的精彩內容，更多的精彩內容請點擊：http://kitchinit.com我們后續會有更多的精彩內容等您查看.

The above is the highlights of the automatic feeding mixer. For more highlights, please click: http://kitchinit.com We will have more wonderful content for you to check later