冷卻系統是攪拌車發動機五大系統中的重要組成部分，而水箱是冷卻系統中重要的部分。攪拌車發動機溫度過高是朋友在運輸過程中的常見現象，也是很多朋友頭疼的問題。發動機溫度高的主要原因是散熱器，也就是水箱，所以水箱的保養是非常必要的。

The cooling system is an important part of the five systems of the mixer engine, and the water tank is an important part of the cooling system. The engine temperature of mixer truck is too high, which is a common phenomenon in the transportation process and a headache for many friends. The main reason for the high engine temperature is the radiator, that is, the water tank, so the maintenance of the water tank is very necessary.

發動機一旦高溫超限，輕的會燒壞氣缸墊，導致缸體、缸蓋變形甚至裂紋，重的會立即熄火。即使發動機在高溫后能正常起動，也已經受到很大的損壞。

Once the engine temperature exceeds the limit, the light engine will burn out the cylinder gasket, resulting in deformation or even cracks of the cylinder block and cylinder head, and the heavy engine will immediately shut down. Even if the engine can start normally after high temperature, it has been greatly damaged.

使用攪拌車水箱防蟲網對外部水箱進行維護為方便。四角有四個鉤子。一旦買好放在水箱前，就可以把鉤子鉤到0公里的任何地方，這樣可以防止夏天柳絮進入水箱的散熱器。即使沒有柳絮，也要安裝防蟲網，因為車輛行駛時，飛蟲等雜物必然會附著在水箱前部。

It is convenient to maintain the external water tank by using the anti insect net of the water tank of the mixer. There are four hooks at the four corners. Once purchased and placed in front of the water tank, the hook can be hooked to any place 0 km away, so as to prevent catkins from entering the radiator of the water tank in summer. Even if there are no catkins, insect proof nets should be installed, because flying insects and other sundries will inevitably adhere to the front of the water tank when the vehicle is driving.

比較簡單的一點，還可以買一個屏風窗，對著前面的水箱，也能起到事半功倍的效果。夏天清洗水箱外時，在這種情況下，柳絮已經附著在水箱或水箱前的中冷器和冷凝器上，而且是一層厚厚的。

A little simpler, you can also buy a screen window, facing the water tank in front, which can also get twice the result with half the effort. When cleaning the outside of the water tank in summer, in this case, catkins have been attached to the water tank or the intercooler and condenser in front of the water tank, and there is a thick layer of catkins.

在不拆卸自動攪拌車水箱的情況下，您可以在某些地方用手將其取下，然后用一根柔軟的空心軟管將其連接到修理工的氣泵上，從發動機側面將其吹出。

Without dismantling the automatic mixer tank, you can remove it by hand in some places, and then connect it to the repairman's air pump with a soft hollow hose to blow it out from the side of the engine.

清洗水箱內部：水箱溫度高很正常。原因是大家都知道，在家里把鋁鍋里的水燒開后，會在鍋底和鍋周圍形成一層厚厚的水垢，非常堅硬，很難清洗。車上的水箱之所以沒有結那么厚，是因為發動機一工作，水箱里的水就一直循環。

Clean the inside of the water tank: the high temperature of the water tank is normal. The reason is that we all know that after boiling the water in the aluminum pot at home, a thick layer of scale will be formed at the bottom and around the pot, which is very hard and difficult to clean. The reason why the water tank on the car is not so thick is that the water in the water tank circulates all the time when the engine works.

但即使一直加水，久而久之仍會在散熱器的水管壁上形成一層水垢，影響發動機的散熱效果，造成高溫。一旦水箱內部堵塞，就需要找專業人員清洗。除了用鋼筋使水箱透明外，還需要用水箱清潔劑去除污垢和鐵銹。然而，這種清洗劑對水箱的腐蝕性很強。

However, even if water is added all the time, a layer of scale will be formed on the water pipe wall of the radiator over time, which will affect the heat dissipation effect of the engine and cause high temperature. Once the inside of the water tank is blocked, it needs to be cleaned by professionals. In addition to making the water tank transparent with steel bars, it is also necessary to remove dirt and rust with water tank cleaner. However, this cleaning agent is highly corrosive to the water tank.

攪拌車上的水箱多應在一兩分鐘內放掉，然后立即用清水沖洗。否則，水箱可能報廢，但清洗效果非常好，與新產品一樣。當水溫控制在佳狀態時，發動機不僅動力強勁，而且可以提高工作效率，節省燃油，延長發動機壽命。

The water tank on the mixer shall be discharged within oneortwo minutes, and then washed with clean water immediately. Otherwise, the water tank may be scrapped, but the cleaning effect is very good, just like the new product. When the water temperature is controlled in a good state, the engine not only has strong power, but also can improve work efficiency, save fuel and prolong engine life.

因為自動攪拌車水箱引起的發動機溫度過高現象屢見不鮮，甚至有些新車也無法控制。主要集中在大廠坡、高原和高溫地區。針對這種情況，好的辦法是增加水箱的散熱面積。

It is common that the engine temperature caused by the water tank of automatic mixer truck is too high, and even some new cars cannot be controlled. Mainly concentrated in Dachang slope, plateau and high temperature areas. In view of this situation, a good way is to increase the heat dissipation area of the water tank.

以上就是今天所要講解的內容了，相信大家在看完本文的描述之后，能夠?qū)υ摦a(chǎn)品有一定的認識和了解，希望以上內容能幫助到你。另外，若你想要了解更多相關資訊，可以多多關注我們的網站動態kitchinit.com。

The above is the content to be explained today. I believe that after reading the description of this article, you can have a certain understanding of the product. I hope the above content can help you. In addition, if you want to learn more about our website, you can pay more attention to our website at www.jfhntjbj com。