攪拌一體車在實施過程中需要掌握好角度，稍有不慎就會翻車，另外施工過程中的臂架震動及地面沉降也可能改變整車點，偏出支腿范圍就會導致整車傾翻。那么在使用過程中需要怎么正確操作呢？

During the implementation of the integrated mixer truck, it is necessary to grasp the angle, and the truck will overturn if it is slightly careless. In addition, the boom vibration and ground settlement during the construction process may also change the center of gravity of the whole vehicle, and the deviation of the center of gravity from the outrigger range will cause the whole vehicle to overturn. So how to operate correctly in the process of use?

一、構成混凝土攪拌一體車的汽車底盤、內燃機、空氣壓縮機、水泵、液壓裝置等的使用，應執行汽車的一般規定及攪拌車的有關規定。

1、 The use of automobile chassis, internal combustion engine, air compressor, water pump, hydraulic device, etc. constituting the concrete mixer shall comply with the general provisions of the automobile and the relevant provisions of the mixer.

二、攪拌車就位地點應平坦堅實，周圍無障礙物，上空無高壓輸電線。攪拌車不得停放在斜坡上。

2、 The location of the mixer truck should be flat and solid, with no obstacles around and no high-voltage transmission lines above. The mixer truck shall not be parked on the slope.

三、攪拌車就位后，應支起支腿并保持機身的水平和穩定。當用布料桿送料時，機身傾斜度不得大于3°。

3、 After the mixer truck is in place, the outriggers should be supported and the level and stability of the fuselage should be maintained. When feeding with a distributing rod, the inclination of the machine body shall not be greater than 3 °.

四、就位后，攪拌車應打開停車燈，避免碰撞。

4、 After being in place, the mixer should turn on the stop light to avoid collision.

五、作業前檢查項目應符合下列要求：

5、 The pre operation inspection items shall meet the following requirements:

1、燃油、潤滑油、液壓油、水箱添加充足，輪胎氣壓符合規定，照明和信號指示燈齊全良好;

1. Sufficient fuel, lubricating oil, hydraulic oil and water tank are added, the tire pressure meets the regulations, and the lighting and signal indicators are complete and good;

2、液壓系統工作正常，管道無泄漏;清洗水泵及設備齊全良好;

2. The hydraulic system works normally and the pipeline has no leakage; The cleaning water pump and equipment are complete and in good condition;

3、攪拌斗內無雜物，料斗上保護格網完好并蓋嚴;

3. There are no sundries in the mixing bucket, and the protective grid on the hopper is intact and tightly covered;

4、輸送管路連接牢固，密封良好。

4. The transmission pipeline is firmly connected and well sealed.

六、布料管所用配管和軟管應按出廠說明書的規定選用，不得使用超過規定直徑的配管，裝接的軟管應拴上防脫帶。

6、 The pipes and hoses used for distributing pipes shall be selected according to the provisions of the factory instructions. Pipes with a diameter exceeding the specified diameter shall not be used, and the hoses installed shall be tied with anti stripping tapes.

七、伸展布料桿應按出廠說明書的順序進行，布料桿升離支架后方可回轉。嚴禁用布料桿起吊或拖拉物件。

7、 The spreading of the boom should be carried out in the order of the factory instructions, and the boom can rotate only after it is lifted away from the support. It is strictly forbidden to lift or drag objects with the cloth boom.

八、當布料桿處于全伸狀態時，不得移動車身。作業中需要移動車身時，應將上段布料桿折疊固定，移動速度不得超過10km/h。

8、 Do not move the body when the boom is fully extended. When the vehicle body needs to be moved during the operation, the upper boom should be folded and fixed, and the moving speed should not exceed 10km / h.

九、不得在地面上拖拉布料桿前端軟管;嚴禁延長布料配管和布料桿。當風力在六級及以上時，不得使用布料桿輸送混凝土。

9、 Do not drag the hose at the front end of the boom on the ground; It is strictly forbidden to extend the distribution pipe and distribution rod. When the wind force is at level 6 or above, it is not allowed to use the boom to transport concrete.

十、攪拌一體車送管道的敷設，應按本規程攪拌車中的第二條的規定執行。

10、 The laying of the delivery pipeline of the integrated mixer truck shall be carried out in accordance with the provisions of Article 2 of this specification.

以上就是問題解答的相關內容了，希望能夠幫助到大家，如對這一問題還存在任何疑問，都歡迎關注我們網站http://kitchinit.com并咨詢我們的工作人員，將竭誠為您服務。

The above is the relevant content of the question answer. I hope it can help you. If you still have any questions about this problem, you are welcome to follow our website http://kitchinit.com And consult our staff, will serve you wholeheartedly.