When using multifunctional concrete mixer, it is inevitable that the water tank will not rotate, but what is the reason? What part do I need to check? Now let's talk about it.

1.發動機故障（并非不可能，隆隆聲）。

1. Engine failure (not impossible, rumbling).

2.檢查液壓油是否泄漏（如果管道破裂，請更換管道，如果管道破裂，請更換密封件）。

2. Check whether the hydraulic oil leaks (if the pipe is broken, replace the pipe, if the pipe is broken, replace the seal).

3.多功能混凝土運輸攪拌車的散熱器風扇旋轉，液壓油未乳化或變白，液壓油溫度超過90度，或液壓系統無壓力。確保水箱沒有旋轉（在這種情況下，請用水）。它可以冷卻液壓泵，液壓馬達和液壓油的溫度并旋轉油箱。清除材料并迅速修理散熱器或更換液壓油。

3. The radiator fan of the multifunctional concrete mixer rotates, the hydraulic oil is not emulsified or white, the temperature of the hydraulic oil exceeds 90 degrees, or the hydraulic system has no pressure. Make sure that the tank does not rotate (in this case, use water). It can cool the temperature of hydraulic pump, hydraulic motor and hydraulic oil and rotate the oil tank. Remove the material and quickly repair the radiator or replace the hydraulic oil.

4.傳動軸的10齒損壞或損壞（a：如果損壞，請立即更換傳動軸。B.傳動軸是否良好）。

4. The 10 teeth of the transmission shaft are damaged or damaged (A: if damaged, please replace the transmission shaft immediately. B. Whether the transmission shaft is in good condition).

5.運輸過程中我很小心，水箱停了下來！混凝土坍塌，水箱無法翻轉（這是您感到有點旋轉的壓力時）。

5. I was very careful during the transportation, the water tank stopped! The concrete collapses and the water tank cannot be turned over (this is when you feel a bit of rotational pressure).

6.液壓泵損壞（情況稍微復雜一些，內部腹瀉嚴重，還有其他損壞）。

6. The hydraulic pump is damaged (the situation is a little more complicated, the internal diarrhea is serious, and there are other damages).

如果發生以上六種情況，混凝土不凝結，液壓馬達和減速器未發生故障，可以使用應急裝置。使用另一臺多功能混凝土運輸攪拌機的液壓泵驅動液壓馬達旋轉水箱，釋放混凝土，然后進行檢查和維修。

If the above six conditions occur, the concrete does not set, and the hydraulic motor and reducer do not fail, the emergency device can be used. Use the hydraulic pump of another multifunctional concrete transport mixer to drive the hydraulic motor to rotate the water tank, release the concrete, and then carry out inspection and maintenance.

全自動攪拌車的零件，無需旋轉即可檢查，歡迎來電咨詢！

Automatic mixer parts, without rotation can be checked, welcome to inquire!