At present, there are three types of automatic feeding mixers: wet materials, dry materials and semi dry materials. If the concrete loader is not operated safely, rollover and hydraulic pump will occur. The wear of motor and reducer is too fast, which may even cause serious consequences. The following small series of articles introduce the following contents according to the safety operation rules to be followed when using the self loading mixer:

1.攪拌筒的旋轉方向必須與箭頭方向一致。如果不正確，則需要更正電動機接線。

1. The rotation direction of the mixing drum must be consistent with the direction of the arrow. If not, correct the motor wiring.

2.設備齊全的混合器必須實施二次泄漏保護。打開電源后即可上班，因此請仔細檢查。僅在通過空車測試后才能使用。在調試期間，請確?；旌瞎薜乃俣日_。通常，空車（裝載后）的速度比幾轉彎稍快。如果相差很大，則需要調整驅動輪與驅動輪的比率。

2. The mixer with complete equipment must be protected against secondary leakage. You can go to work after turning on the power, so please check carefully. It can only be used after passing the empty vehicle test. During commissioning, please ensure that the mixing tank speed is correct. Generally, the speed of an empty vehicle (after loading) is slightly faster than that of a few turns. If there is a large difference, the ratio of drive wheel to drive wheel needs to be adjusted.

3.攪拌機軌道應平放。用一棵方形樹抬起前后軸，使輪胎直立，以免輪胎在開始時移動。

3. The mixer track shall be placed horizontally. Lift the front and rear axles with a square tree to keep the tire upright so that the tire does not move at the beginning.

4，.變速箱離合器，制動器是否靈活可靠，鋼絲繩是否完好，履帶輪是否完好，周圍是否有障礙物，各部位的潤滑確保。

4. Whether the gearbox clutch and brake are flexible and reliable, whether the steel wire rope is intact, whether the crawler wheel is intact, whether there are obstacles around, and whether the lubrication of all parts is ensured.

5.如果您正在攪拌混凝土，或者您打算停止攪拌一個小時以上（除了其余材料），則將石頭和水倒入桶中，將其打開，洗掉粘附在桶上的砂漿并瀝干所有東西。去做。槍管中應該沒有水，以防止槍管和刀片生銹。同時，必須清除積聚在混合罐外部的灰燼，并保持機器清潔并保持良好狀態。

5. If you are mixing concrete, or you intend to stop mixing for more than an hour (except for other materials), pour stones and water into the bucket, open it, wash off the mortar adhered to the bucket and drain everything. Do it. There should be no water in the barrel to prevent the barrel and blade from rusting. At the same time, ash accumulated outside the mixing tank must be removed and the machine must be kept clean and in good condition.

6.啟動后，請注意調音臺各部分的正常運行。關閉時，請始終檢查攪拌機葉片是否彎曲，擰松或松動。

6. After startup, please pay attention to the normal operation of all parts of the mixer. When closing, always check whether the mixer blades are bent, loosened or loose.

7.下班后，不使用機器時，有必要關閉電源并鎖定開關盒，以確保安全。

7. After work, when the machine is not used, it is necessary to turn off the power supply and lock the switch box to ensure safety.

以上是使用自動上料攪拌車時要遵循的安全操作規則。我認為以后使用會更加謹慎。需要更多信息嗎？請繼續關注我們http://kitchinit.com

The above are the safety operation rules to be followed when using automatic feeding mixer. I think it will be used more carefully in the future. Need more information? Please continue to follow us http://kitchinit.com