The operator of automatic loading mixer truck is mainly responsible for the daily production of concrete mixing equipment. The operator should have practical operation experience in the mixing plant and be familiar with the equipment software, PLC and other operations of the mixing plant. Here is a summary of the post responsibilities of the computer operator of automatic loading mixer truck.

一、 混凝土攪拌樓電腦操作工必須嚴格遵守公司的一切規章制度。

1、 The computer operator of concrete mixing plant must strictly abide by all rules and regulations of the company.

二、 嚴禁將本公司的砼配合比資料及原材料對外泄露，一旦發現堅 決給予開除

2、 It is strictly prohibited to disclose the concrete mix proportion data and raw materials of the company. Once found, it shall be resolutely dismissed

三、 每次開機前，必須對攪拌機檢查是否正常，查看交接班記錄， 巡視一切正常后方可開機。

3、 Before starting up each time, check whether the mixer is normal, check the shift handover record, and start up only after everything is normal.

四、 操作工開工前必須對操作室預熱，然后打打鈴3次，每次不得 少于3秒。

4、 The operator must preheat the operation room before starting work, and then ring the bell for 3 times, each time not less than 3 seconds.

五、 嚴格按配合比單正確操作電腦，不能隨意更改配合比單，如需 更改必須由試驗室人員現場監督簽字。

5、 Operate the computer correctly in strict accordance with the mix proportion sheet, and do not change the mix proportion sheet at will. If it needs to be changed, it must be signed by the laboratory personnel on site.

六、 嚴格按調度規定的指令發出信號，即：生產前、裝料前、裝料 后發出鈴聲。

6、 Send signals in strict accordance with the instructions specified by the dispatcher, i.e. ring before production, before loading and after loading.

七、 正常工作2小時，操作工必須巡視攪拌機，清理攪拌機。

7、 When working normally for 2 hours, the operator must patrol the mixer and clean it.

八、 若有聽到異響或聞到異味必須立即停機，及時向上級匯報。

8、 If you hear abnormal noise or smell peculiar smell, you must stop the machine immediately and report to the superior in time.

九、 危險部位維修或搶修時，必須停機后把操作臺上控制鑰匙交到 施工人員手中，并且操作工在現場監督。

9、 In case of repair or emergency repair of dangerous parts, the control key on the console must be handed over to the construction personnel after shutdown, and the operator shall supervise on site.

十、 密切注意操作臺上各種數據的變化，發現有異常情況及時通知 相關人員進行故障排除。

10、 Pay close attention to the changes of various data on the console, and timely notify relevant personnel for troubleshooting in case of abnormalities.

十一、 操作工報廢料時，必須由主管導同意，查看原因所在， 并如實填寫材料報廢登記表

11、 When the operator reports the waste, he must be approved by the supervisor, check the reason, and truthfully fill in the material scrap registration form

十二、 操作室嚴禁吸煙，設備要求清潔，嚴禁無關人員進入操作 室，如有違章按公司處罰條例執行。

12、 Smoking is strictly prohibited in the operation room. The equipment shall be clean. Irrelevant personnel are strictly prohibited from entering the operation room. In case of violation, the punishment regulations of the company shall be implemented.

十三、 操作室內嚴禁放與生產無關的東西，嚴禁在電腦上玩游戲 或光盤；電腦上所有設置不允許隨意改動。

13、 It is strictly prohibited to put anything irrelevant to production in the operation room, and it is strictly prohibited to play games or CDs on the computer; All settings on the computer are not allowed to be changed at will.

十四、 不裝料時，操作員嚴禁離開自己的崗位，保證崗不離人， 如有違章按公司離崗條例處罰。 十五、 操作時發現有明顯的產品質量問題，應及時停機，由試驗 室來確定。

14、 When not loading, the operator is strictly forbidden to leave his post and ensure that he will not leave his post. If there is any violation, he shall be punished according to the company's regulations on leaving his post. 15、 If obvious product quality problems are found during operation, the machine shall be shut down in time and determined by the laboratory.

十六、 做好相關工作時必須以安全為前提，確認安全后方可開工。

16、 Safety must be taken as the premise when doing relevant work, and the construction can be started only after confirming safety.

十七、 保持?jǐn)嚢铇呛筒僮魇艺麧嵭l(wèi)生，收工時必須對攪拌機 清洗，所有電源必須切斷，門窗鎖好、關嚴。

17、 Keep the mixing plant and operation room clean and tidy. The mixer must be cleaned at the end of work. All power supplies must be cut off, and the doors and windows must be locked and tightly closed.

十八、 認真做好攪拌樓生產記錄及原材料消耗情況。

18、 Carefully make production records and raw material consumption of the mixing plant.

十九、 認真完成組長交給的臨時工作任務。

19、 Earnestly complete the temporary tasks assigned by the team leader.

二十、 及時配合機修工對設備的維護、檢修等工作

20、 Timely cooperate with the mechanic to maintain and repair the equipment